What should be paid attention to when driving concrete mixer? What experience do you have in driving mixer? Many people have this problem, especially new drivers. Xiaobian has always been committed to solving the problem of "concrete line" for you, so we specially arranged some practical experience of starting mixer, hope you can move your hand.

　　1. 出门前要注意检查

　　1. Pay attention to inspection before going out

　　1. 认真检查，及时发现和排除故障。

　　1. Check carefully, find out and eliminate faults in time.

　　从来没有重型汽车在道路上断裂，否则会有麻烦，混凝土一般不能停止超过2小时，C40级的混凝土不能停止。

　　No heavy vehicle has ever broken on the road, otherwise there will be trouble. Generally, the concrete cannot be stopped for more than 2 hours, and the concrete of C40 grade cannot be stopped.

　　点火前应检查机油、防冻剂、润滑油、冷却水等，如发现不足，应重新补充。

　　Check the engine oil, antifreeze, lubricating oil, cooling water, etc. before ignition, and replenish them if found insufficient.

　　汽车启动后,然后让锅旋转速度低,在汽车检查轮胎压力,是否有漏气的轮胎,然后使用螺丝刀拆卸轮胎的石头差距,检查是否有钉子等困在轮胎!

　　After the car starts, then let the pot rotate at a low speed. Check the tire pressure in the car, and check whether there is a leaking tire. Then use a screwdriver to remove the stone gap of the tire, and check whether there are nails trapped in the tire!

　　再检查一下车灯，尤其是腰部的车灯，一定要照射在轮胎的边缘上，工地上往往会杂乱地堆放着钢材之类的东西，而轮胎的侧面是薄弱的。

　　Check the light again, especially the light at the waist, and make sure it shines on the edge of the tire. Steel and other things are often piled up disorderly on the construction site, and the side of the tire is the weakest.

　　用抹布、窗玻璃擦拭两边的后视镜，施工现场条件复杂，光线不好，视线必须保证!

　　Wipe the rear-view mirrors on both sides with rags and windows. The construction site conditions are complex and the light is not good. The line of sight must be guaranteed first!

　　再检查一下车灯，尤其是腰部的车灯，一定要照射在轮胎的边缘上，工地上往往会杂乱地堆放着钢材之类的东西，而轮胎的侧面是薄弱的。

　　Check the light again, especially the light at the waist, and make sure it shines on the edge of the tire. Steel and other things are often piled up disorderly on the construction site, and the side of the tire is the weakest.

　　用抹布、窗玻璃擦拭两边的后视镜，施工现场条件复杂，光线不好，视线必须保证!

　　Wipe the rear-view mirrors on both sides with rags and windows. The construction site conditions are complex and the light is not good. The line of sight must be guaranteed first!

　　2. 确保水箱和减水剂中有足够的水。

　　2. Make sure there is enough water in the water tank and water reducer.

　　由于各种原因，材料太干，没有水添加出来的材料，是一条救生索，

　　Due to various reasons, the material is too dry and there is no material added by water. It is a lifeline,

　　3.确保搅拌槽处于停止状态。

　　3. Make sure the mixing tank is stopped.

　　因为当发动机启动时，万一油箱高速旋转，瞬时力就会很大，减速机就会受到伤害。

　　Because when the engine starts, if the oil tank rotates at a high speed, the instantaneous force will be great, and the reducer will be hurt.

　　二、装料时记得清洗

　　2、 Remember to clean when loading

　　1. 装料前把搅拌桶倒过来。

　　1. Turn the mixing barrel over before loading.

　　特殊车辆停放在露天，有雨，水箱内的水可能是树叶等杂物，以免影响混凝土的质量。

　　Special vehicles are parked in the open, with rain, the water in the water tank may be leaves and other debris, so as to avoid affecting the quality of concrete.

　　2. 装完货后，记得把料斗冲洗干净。

　　2. Remember to wash the hopper after loading.

　　清洗后水箱要关闭进气口，打开水箱排出的气体，因为在空气压力下，水管连接不好，容易渗漏，影响其他车辆的。

　　After cleaning, the air inlet of the water tank shall be closed and the gas discharged from the water tank shall be opened, because under the air pressure, the water pipe is not well connected and easy to leak, which affects the safety of other vehicles.

　　再次检查轮胎是否有石子和钉子，因为停车时不可能检查轮胎接触地面的地方。

　　Check the tires again for stones and nails, as it is not possible to check where the tires touch the ground when parking.

　　2. 卸料前把料斗滑槽弄湿。

　　2. Wet the hopper chute before discharging.

　　卸料时，将车停在地面上，尽量在卸料前将料斗滑槽弄湿，便于清洗。

　　When unloading, park the car on the ground, and try to wet the hopper chute before unloading to facilitate cleaning.

　　3、不要在不经意间放电和放电之间的良好关系。

　　3. Do not inadvertently discharge and discharge the good relationship between.

　　是自己看材料，这样才不会把材料工人的操作乱了，操作杆上的材料，每次锅正转和反转中间的座位好停止，保护减速器，支撑轮等。

　　It's better to see the materials by yourself, so as not to mess up the operation of the material workers. For the materials on the operating rod, it's better to stop the seat between the forward and reverse rotation of the pot every time, protect the reducer, support wheel, etc.

　　与卸料打好关系，卸料也不要睡得太好，万一心情不好，工人把你的车放到工地上不要转锅，造成了麻烦。

　　Make a good relationship with unloading, and do not sleep too well during unloading. In case of bad mood, the workers will put your car on the construction site and do not turn the pot, causing trouble.

　　4. 一定要把混合槽彻底冲洗干净。

　　4. Be sure to wash the mixing tank thoroughly.

　　清洗水箱时一定要仔细清洗干净，并将水反复正负转两圈，然后放出来，后一次将水箱全部倒入水箱中，然后再回到站内加水彻底清洗水箱。

　　When cleaning the water tank, it must be cleaned carefully, and the water shall be repeatedly turned positive and negative for two circles, then put out, pour the water tank into the water tank for the last time, and then return to the station to add water to thoroughly clean the water tank.

　　以上就是对使用中科搅拌车过程中不可忽视的细节的详细介绍，希望可以帮到你！想要了解更多请点击官网https://www.cnzkjf.com

　　The above is a detailed introduction to the details that can not be ignored in the process of using Zhongke mixer. I hope it can help you! To learn more, please click https://www.cnzkjf.com