As we all know, the Department self loading concrete mixer has a very important role in the construction industry. It is very convenient to use the concrete construction industry. But because the quality of the loaded concrete mixer is good or bad, it is one-sided and understanding for many friends. In fact, a qualified self mixing feeding vehicle also needs to meet the following standards, which can be considered as qualified.

　　整车外形尺寸应符合标准。并根据批准的产品图纸和技术文件进行制造。

　　The overall dimensions of the whole vehicle shall meet the national standards. And manufacture according to the approved product drawings and technical documents.

　　外购件和外购件应具有生产厂家的产品合格证，并符合相关标准要求，经搅拌车生产厂家检验合格后方可装配。

　　The purchased parts and purchased parts shall have the product certificate of the manufacturer and meet the requirements of relevant standards, and can be assembled only after passing the inspection of the mixer manufacturer.

　　装载机的总质量不得超过底盘的许用值，转向轴(轮)的载重质量及横摇稳定性角应符合有关规定。

　　The total mass of the loader shall not exceed the allowable value of the chassis, and the load mass and roll stability angle of the steering shaft (wheel) shall meet the relevant regulations.

　　焊缝应平整、笔直。无漏焊、裂纹、渣、表面应无毛刺、覆砂现象。

　　The weld shall be flat and straight. There shall be no missing welding, crack, center slag, burr and sand covering on the surface.

　　所有裸露的黑色金属表面应进行防锈处理。外观装修漆应美观大方，符合有关规定。

　　All exposed ferrous surfaces shall be rust protected. The exterior decoration paint shall be beautiful and conform to relevant regulations.

　　自上料后，搅拌车的出料速度不小于0.65m3/min，出料残留率小于2-5%。搅拌车进料速度不小于2.7m3/min

　　After feeding, the discharging speed of the mixer shall not be less than 0.65m3/min, and the discharging residual rate shall be less than 2-5%. The feeding speed of mixer shall not be less than 2.7m3/min

　　从进料到出料，允许的长时间为90mh，搅拌筒的连续输送按规定不超过300转。搅拌车自进料后，速度不得超过50km/h。

　　The allowable long time from feeding to discharging is 90mh, and the continuous conveying of mixing drum shall not exceed 300 revolutions as required. After the mixer is fed, the speed shall not exceed 50km / h.

　　混合混凝土按规定的搅拌速度和运输时间运交付地点后，其胶结土质量应符合标准要求。

　　After the mixed concrete is transported to the delivery place according to the specified mixing speed and transportation time, its cemented soil quality shall meet the requirements of national standards.

　　进料斗出料口尺寸不小于650mm，离地高度不大于3.8m。

　　The size of the feed hopper outlet shall not be less than 650mm, and the height from the ground shall not be more than 3.8m.

　　自上料后，搅拌车的出料速度不小于0.65m3/min，出料残留率小于2-5%。搅拌车进料速度不小于2.7m3/min[详见《一键式开式自走式搅拌车正确驾驶姿势》相关内容]

　　After feeding, the discharging speed of the mixer shall not be less than 0.65m3/min, and the discharging residual rate shall be less than 2-5%. The feeding speed of the mixer shall not be less than 2.7m3/min [for details, please refer to the relevant contents of the correct driving posture of the one key open self-propelled mixer]

　　在总质量较大的情况下，加载搅拌机以20km/h的速度从加载搅拌机处溢出14%的坡道

　　In case of large total mass, the loading mixer overflows 14% ramp from the loading mixer at 20km / h

　　交货应安装牢固。连接部件不得损坏、变形，车辆与底盘之间不得偏离原固定装置。

　　The delivery shall be installed firmly. The connecting parts shall not be damaged or deformed, and the vehicle and chassis shall not deviate from the original fixing device.

　　在总质量较大的情况下，加载搅拌机以20km/h的速度从加载搅拌机处溢出14%的坡道。

　　In case of large total mass, the loading mixer overflows 14% ramp from the loading mixer at the speed of 20km / h.

　　制动性能符合标准。车辆外部噪声应符合标准。

　　The braking performance meets the national standard. The external noise of vehicle shall meet the national standard.

　　车辆的密封性能良好，密封面、管接头及所有连接件不允许有漏油现象。

　　The sealing performance of the vehicle is good, and the sealing surface, pipe joint and all connecting parts are not allowed to have oil leakage.

　　以上为判断搅拌车是否合格进料的标准。希望本文的介绍能对您有所帮助。当然，我们在这方面还有很多的知识，我们会在下面继续与大家分享，大家可以继续关注我们的网站:www.cnzkjf.com，谢谢大家的支持。

　　The above is the standard to judge whether the mixer is qualified for feeding. I hope this introduction can help you. Of course, we have a lot of knowledge in this area. We will continue to share with you below. You can continue to pay attention to our website: www.cnzkjf.com. Thank you for your support.