Many users don't care about this item. The drying tank of the concrete self-feeding mixer is no stranger to everyone. It is used to filter the water vapor in the compressed air in the air path system to prevent the corrosion of the air reservoir and various pump valves. Therefore, whether the drying tank of the concrete self-feeding mixer can work normally directly affects the brake performance.

现实中却有多卡友因为对干燥罐认识不全，而经常忽略它的存在。混凝土自上料搅拌机干燥罐虽然不贵，但是很多用户还是能省就省，对干燥罐的品质也无所谓，只要有一个能用就行，有的甚几年都不换一次。

In reality, there are many Dokayou who often ignore the existence of the drying tank because they do not fully understand it. Although the drying tank of the concrete self-feeding mixer is not expensive, many users can save it and have no concern about the quality of the drying tank. As long as one can be used, some do not even change it for several years.

干燥罐一定要买企业的，有个司机朋友刚换了没多久的劣质干燥罐就失效了，结果刹车分泵内进水结冰导致刹车失灵。

The drying tank must be of a brand. A friend of the driver just replaced the inferior drying tank and it failed. As a result, the brake wheel cylinder was filled with water and ice, resulting in brake failure.

混凝土自上料搅拌机更换干燥罐的操作并不繁琐，利用气罐底部的放气阀门，来查看气罐底部是否潮湿，或者有水。如果干燥罐失效，打开阀门之后会有水流出，应该立即更换新的干燥罐。

The operation of replacing the drying tank with the concrete self-feeding mixer is not complicated. Use the vent valve at the bottom of the air tank to check whether the bottom of the air tank is wet or there is water. If the drying tank fails, water will flow out after opening the valve, and a new drying tank should be replaced immediately.

好多人都是只要不出问题，几年可能都不会换一次。并且不同企业的干燥罐使用寿命不一样，而且车辆行驶的气候环境也有差异，更换的周期就很难统一。

Many people may not change once in a few years as long as there is no problem. In addition, the service life of drying tanks of different brands is different, and the climate environment of vehicles is also different, so it is difficult to unify the replacement cycle.

如果混凝土自上料搅拌机司机们实在不知道何时该更换，可以通过查看储气筒是否有积水的方法来判断。但是在这里也要提醒司机朋友们，因为混凝土自上料搅拌机干燥罐连接着气路，罐体内部与外界有一定的压力差，压缩空气未排空时冒然拆卸，压缩空气瞬间释放，易对拆卸人员造成伤害。

If the concrete self-feeding mixer drivers really don't know when to replace it, they can judge by checking whether there is water in the air reservoir. But here, we should also remind drivers that because the drying tank of the concrete self-feeding mixer is connected to the gas path, there is a certain pressure difference between the tank body and the outside. When the compressed air is not emptied, it will be dismantled boldly, and the compressed air will be released instantaneously, which is easy to cause injury to the dismantling personnel.

所以，一定要排空储气筒内空气（反复踩踏刹车，直气压表读数归零），才可以对干燥罐进行拆卸。借助专用的扳手将干燥罐拆卸下来之后，可以在底座上看到有星星点点的水珠，可见压缩空气的湿度还是很大的。

Therefore, it is necessary to empty the air in the air reservoir (repeatedly press the brake until the barometer reading returns to zero) before disassembling the drying tank. After disassembling the drying tank with the help of a special wrench, you can see the water droplets on the base. It can be seen that the humidity of the compressed air is still high.

如果干燥罐的过滤效果差的话，这些液态水就会由气路进入到刹车的各个泵阀。在安装新的干燥罐之前，要将底座上面清理一下，防止油污进入新罐的内部，影响性能。

If the filtering effect of the drying tank is poor, the liquid water will enter each pump valve of the brake through the air path. Before installing a new drying tank, first clean the base to prevent oil dirt from entering the inside of the new tank and affecting the dehumidification performance.

然后在新干燥罐下面的橡胶垫圈上要涂抹一层机油，起到润滑的作用，防止安装时损坏橡胶垫圈。

Then apply a layer of oil on the rubber washer under the new drying tank to lubricate and prevent damage to the rubber washer during installation.

混凝土自上料搅拌机影响刹车性能的原因有很多，混凝土自上料搅拌机干燥罐就是不可忽略的一个重要因素，如果使用劣质产品，或者长时间不更换导致性能丧失,将会严重影响整车的制动。

There are many reasons why the concrete self-feeding mixer affects the brake performance, and the drying tank of the concrete self-feeding mixer is an important factor that cannot be ignored. If inferior products are used, or if they are not replaced for a long time, the loss of dehumidification performance will seriously affect the brake of the whole vehicle.

感谢您的阅读，此文的文章来源： 中科搅拌机更多的内容和问题请点击：https://www.cnzkjf.com我们会继续努力的为您提供服务，感谢您的支持！

Thank you for reading. The source of this article is: Zhongke Mixer. For more information and questions, please click: https://www.cnzkjf.com We will continue to work hard to provide you with services. Thank you for your support!