移动式搅拌车由汽车底盘和混凝土搅拌运输专用装置组成，其专用机构主要包括取力器、搅拌筒前后支架、减速机、液压系统、搅拌筒、操纵机构、清洗系统等。移动式搅拌车工作原理是通过取力装置将汽车底盘的动力取出，并驱动液压系统的变量泵，把机械能转化为液压能传给定量马达，马达再驱动减速机，由减速机驱动搅拌装置，对混凝土进行搅拌。
The mobile mixer truck is composed of a car chassis and a special device for concrete mixing and transportation. Its special mechanism mainly includes power takeoff, front and rear supports of mixing drum, reducer, hydraulic system, mixing drum, control mechanism, cleaning system, etc. The working principle of the mobile mixer truck is to take out the power of the vehicle chassis through the power take-off device, drive the variable pump of the hydraulic system, convert the mechanical energy into hydraulic energy and transmit it to the quantitative motor. The motor then drives the reducer, and the reducer drives the mixing device to mix the concrete.
1、混凝土搅拌车运送混凝土时，发动机转速在1000-1400转/分范围内工作，在运送混凝土过程中，车速不得超过40km/h。
1. When the concrete mixer truck is transporting concrete, the engine speed shall be within the range of 1000-1400 rpm, and the speed shall not exceed 40km / h during the transportation of concrete.
2、搅拌车工作完毕，应把搅拌筒内部和车身清洗干净，不能使剩余的混凝土留在筒内。
2. After the work of the mixer truck is completed, the interior and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.
3、搅拌车在水泵工作时，禁止空转，连续使用时不要超过15分钟。
3. When the water pump of the mixer truck is working, it is forbidden to idle, and the continuous use shall not exceed 15 minutes.
4、混凝土搅拌车水箱的水量要经常保持装满，以备急用，冬季停机后，应将水箱、水泵、水管、搅拌筒内的水放净，并停放在朝阳、不积水的地方，以免冻坏机械。
4. The water volume of the water tank of the concrete mixer truck shall be kept full for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum shall be drained and parked in a place with no ponding in the sun to avoid freezing the machine.
5、搅拌车在冬季应及时安装保温套，并使用防冻液对搅拌车加以保护，根据天气变化更换燃油标号，保障机械的正常使用。
5. In winter, the mixer truck shall be timely installed with thermal insulation sleeve, protected with antifreeze, and the fuel grade shall be changed according to the weather change to ensure the normal use of the machinery.
6、在检查、修理搅拌车液压传动部分时，应使发动机和液压泵在没有压力的情况下进行。
6. When inspecting and repairing the hydraulic transmission part of the mixer truck, the engine and hydraulic pump shall be operated without pressure.
1、还请您留下详细的收货地址，以便于后期为您填写货物运单，运单内容填写的准确性对到站及时向您发出催领通知有很大的帮助。
1. Please also leave a detailed receiving address so that you can fill in the cargo waybill for you later. The accuracy of the content of the waybill is very helpful to send you a reminder notice in time at the arrival station.
2、运单中收货人名称的填写十分重要，收货人是个人的应与本人的身份证姓名相吻合，收货人是单位的应与公章及单位全称相吻合。
2. It is very important to fill in the name of the consignee in the waybill. If the consignee is an individual, it should be consistent with the name of his I.
3、领货凭证您应妥善保管，它是收货人在到站领取货物的重要凭证，一旦丢失会给收货人在到站的交付手续增添很多麻烦。
3. You should keep the receiving certificate properly. It is an important certificate for the consignee to receive the goods at the arrival station. Once it is lost, it will add a lot of trouble to the delivery procedures of the consignee at the arrival station.
The above is a detailed introduction about Zhongke concrete mixer. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service https://www.cnzkjf.com
